Non-adherence to SOPs by pilot led to last year's Air India Express crash in Kerala: Report

"'The probable cause of the accident was the non adherence to standard operating procedures by the pilot flying, wherein, he continued an unstabilized approach and landed beyond the touchdown zone, half way down the runway, in spite of 'Go Around' call by [the] Pilot Monitoring which warranted a mandatory 'Go Around' and the failure of the Pilot Monitoring to take over controls and execute a 'Go Around'," said the 257-page report by Aircraft Accident Investigation Bureau, according to NDTV.

After the pilot failed to land twice due to bad weather, the plane touched down on the tabletop runway but overshot it. It fell into the adjoining valley and broke into three pieces.

"Before the approach for runway 10 as well, the Pilot in Command did not carry out adequate briefing for landing with tailwinds, in rain and poor visibility. The mandatory calculation of landing distances was omitted. Alternate airfields most suited for 'diversions' in case of second missed approach under the prevailing weather conditions and unserviceable windshield wiper were not covered during the briefing,'' the report said.

"This was a violation of the SOP, and the error magnified on this approach as the landing was made in strong tail wind condition on a wet tabletop runway in active rain," it added.

The report further said, ''The crew were experienced and had often operated in Indian monsoon conditions. They were aware of the adverse weather Standard Operating Procedures of Kozhikode. The Pilot in Command took a decision not to divert after the 'missed approach' on runway 28 even though there were alternate airfields available in close proximity and there was enough fuel on board.

"Subsequently, without any risk assessment, the Pilot in Command continued for a second approach into Kozhikode. The First Officer did not give any input regarding this gross SOP violation to the Pilot in Command, indicating a steep cockpit authority gradient resulting in poor Crew Resource Management,'' it added.

The report stated that the flying officer had "correctly identified that the approach for runway 10 was an 'unstabilized approach'".

                         GALLERY OF THE CRASH LAST YEAR

 "After making two unassertive attempts to attract the Pilot in Command's attention towards the unstabilized approach, using non-standard vocabulary, he asked the Pilot in Command to 'Go Around' just before touchdown. In spite of knowing full well that the approach was unstabilized and the Pilot in Command was not responding, the First Officer did not take over the controls as per the company Standard Operating Procedures and initiate a 'Go Around','' the report stated.

Pointing at the systemic failures that contributed to the fatal accident, the report said, "A large number of similar accidents/ incidents that have continued to take place, more so in AIXL, reinforce existing systemic failures within the aviation sector.

"These usually occur due to prevailing safety culture that give rise to errors, mistakes and violation of routine tasks performed by people operating within the system. Hence, the contributory factors enumerated below include both the immediate causes and the deeper or systemic causes," it added.

Highlighting the "faulty" HR policy of Air India Express Limited (AIXL), the report said, ''The actions and decisions of the PIC were steered by a misplaced motivation to land back at Kozhikode to operate next day morning flight AXB 1373. 

"The unavailability of sufficient number of Captains at Kozhikode was the result of faulty AIXL HR policy which does not take into account operational requirement while assigning permanent base to its Captains. There was only 01 Captain against 26 First Officers on the posted strength at Kozhikode."